Announcement

Collapse
No announcement yet.

.204 Ruger FAQ

Collapse

Unconfigured Ad Widget

Collapse
This is a sticky topic.
X
X
  • Filter
  • Time
  • Show
Clear All
new posts

  • .204 Ruger FAQ

    The .204 Ruger is a centerfire rifle cartridge developed by Hornady and Ruger. At the time of its introduction in 2004, the .204 Ruger was the highest velocity commercially produced ammunition, and the only cartridge produced commercially for bullets of .204 inch/5 mm caliber.

    The .204 Ruger was developed from the .222 Remington Magnum, which has the second largest case capacity in the family that began with the .222 Remington. Only the European 5.6x50 Magnum is larger, which itself is a lengthened version of the .222 Remington Magnum. The .222 Rem. Mag. provides about 10% more case capacity than the most popular member of the family, the NATO 5.56×45 mm (.223 Rem). To make the .204, the .222 Rem. Mag. was necked down to .204 inches (5 mm). Bullets available in .20 caliber range from 26 to 50 grains (1.7 to 3.25g), and although the selection is limited, it is growing as the cartridge gains wider popularity. The Hornady factory load is listed at 4,225 ft/s (1288 m/s) with a 32-grain (2.1 g) bullet. To achieve these velocities, the factory uses a proprietary powder composition specially formulated by Primex for the .204 Ruger, known internally as SMP746, and not currently (2009) available to handloaders. The propellant features a de-coppering agent that helps prevent fouling. Reloading data from Hornady, using commercially available powders, indicates velocity peaking at just under 4,200 ft/s (1,300 m/s) with the 32-grain (2.1 g) bullet. Many AR-15 rifle manufacturers, including Remington, now offer .204 Ruger as an alternative chambering alongside the usual 5.56mm/.223.

    The .204 Ruger was the second Ruger-named cartridge produced by a partnership between Ruger and Hornady, the first being the big bore .480 Ruger revolver cartridge, introduced in 2003 for the Super Redhawk. With the backing of a major gunmaker and a major ammunition company, the round was an instant success, with other ammunition makers and firearms makers quickly producing offerings in the new caliber. Ruger's initial offerings included the bolt action Model 77 MKII, and the single shot Ruger No. 1, and Hornady offered loadings with 30-and-40-grain (1.9 and 2.6 g) bullets.
    The .204 Ruger has proven to be a very accurate and efficient cartridge: an early tester reported 1/2 MOA groups at 100 yards (91 m) with the Hornady loads and a Ruger #1 Varmint rifle. This is not surprising, considering that the first cartridge in the family, the .222 Remington, was a top benchrest shooting cartridge for many years after its introduction.

    The .204 Ruger was intended primarily for varmint rifles, which require bullets with flat trajectories but not much mass or kinetic energy. The .20 was "splitting the difference" between the popular .22 varmint rounds such as the .220 Swift and .22-250 Remington, and the tiny .17 caliber rounds such as the .17 Remington and the .17 HMR. The resulting cartridge provides somewhat higher velocities than any of these, giving a maximum point blank range of more than 270 yards (250 m).

    Ruger's claim to being the velocity king with the .204 was based on two points. First, other 4000+ ft/s cartridges were wildcats, not commercially produced; the 5mm/35 SMc, for example, can reach 4,800 ft/s (1,500 m/s) using a 30-grain (1.9 g) bullet.

    Second, the ammunition used to achieve the 4200+ ft/s was only available from Hornady using a special powder not available to the general public.[2] Handloaders typically achieve velocities more in the area of 4,050 ft/s (1,230 m/s) using a 32-grain (2.1 g) bullet.[3] Note that handloads using a 40-grain (2.6 g) bullet in other commercial cartridges such as the .220 Swift and .223 WSSM also achieve similar velocities to the .204 Ruger. The advantage of the .20 caliber .204 is that it achieves these velocities using less powder, less recoil, less heat, and better air resistance than the heavier cartridges. The 204 Ruger has a maximum range of approximately 500 yards (460 m).
Working...
X